1911Forum banner

Determining Recoil Spring Specs - Mechanical Engineers Welcome

1 reading
5.9K views 24 replies 12 participants last post by  Rwehavinfunyet  
#1 ·
Okay, in recent purchase of various 1911 parts, I have gotten two unknown 1911 recoil springs. I'm trying to determine their Force / rating. I have a NOS USGI spring for comparison. Below are the details, as measured:

USGI
Free length: 6.55"; Coil outer diameter: 0.438"; Wire diameter: 0.044"; # of coils: 30
Usually listed as a "16-lb" spring

Unknown #1
Free length: 5.88"; Coil outer diameter: 0.435"; Wire diameter: 0.046"; # of coils: 34

Unknown #2
Free length: 6.88", Coil outer diameter: 0.420"; Wire diameter: 0.038"; # of coils: 44

Thanks in advance.
 
#2 ·
Are the unknown springs new? The one being about an inch shorter than the USGI could indicate used, having taken a set, or, maybe it's a Commander spring.

Assuming similar temper, you can figure the smaller diameter wire is a lighter spring, and the larger, heavier. Is the coil spacing even, or are some spaced smaller on one end? This could indicate a variable rate spring.

Since we don't know the material or temper, the only real way to tell is by testing. Such as, how much weight is needed to compress the spring(s) one inch? If not a variable spring, this would give you a value. Ther4eby, a 16-lb spring (non-variable) should show one inch compression with 16 pounds of weight.
 
#4 ·
Recoil spring power is not measured at 1 inch of compression. That value would be spring rate.

The 16 lbs of tension occurs at about 4.9" of compression.

The shear modulus used for spring rate is based on the modulus of elasticity, which doesn't vary much for common spring wire at about 29,000,000 lbs / square inch.
It's safe to say that spring wire is spring wire, at least for our purposes.

-
 
#3 · (Edited)
The spring power for the unknown springs can be calculated by comparing to a spring with known power and dimensions.

Using a 16 lb Wolff govt model spring for reference, this spring has the following relevant dimensions:
free length 6.5"
active coils 31
wire diameter .045"
mean coil diameter .386"

Using a compressed length of 1.625", the rate is simply given by compressed tension / (free length - compressed length)
which equals 16.0 / (6.5 - 1.625)
which equals 3.28 lb / inch

The spring rate K, of the unknown springs is calculated by using the proportional relationship of three parameters:

K is proportional to the wire diameter (d) raised to the 4th power
K is inversely proportional to the mean coil diameter (D) raised to the 3rd power
K is inversely proportional to the number of free coils (N)

For your first spring, the wire diameter changes d in proportion to (.044 / .045) ^ 4 which equals .914
The mean coil diameter changes D in inverse proportion to (.394 / .386) ^ 3 which equals 1.06
The number of free coils changes N in inverse proportion to (30 / 31) which equals .968

So the unknown spring rate equals 3.28 x .914 / (1.06 x .968) which equals 2.92 lb / inch

The unknown spring power is then 2.92 x (6.55 - 1.625) which equals 14.4 lb
Interesting. Sounds like an ordnance power spring.

Simple, no?

I am assuming that one end of your springs are closed, and that you are counting active coils?
Confirm, and I will do the others.

-
 
#5 ·
True. I was unclear and implied 1 inch would be 16 pounds and that is incorrect. I had intended to say that the force applied by 1 inch compression would show differences in the springs, if any. The military print lists 2.88 lb/in for the spring rate.

Thanks for the clear explanation and setting things straight.
 
#6 ·
Measuring the tension at 1 inch of deflection is certainly one way do it. You can then find the spring power from the free length and the compressed length of 1.625".

Note that the actual spring power also depends on the free length. A spring could have a lower spring rate, and a longer free length, and still have the same compressed tension at 1.625".

And of course you could simply measure the tension at the compressed length of 1.625" directly, if you have a good pull scale.

-
 
#7 ·
My rule of thumb is that when it comes to springs is if I can’t easily identify the specific spring and it’s condition (new or used) I simply throw it away. Springs are cheap but the damage that can be done when an inappropriate spring is used can be great. Recoil springs are a consumable so throwing them in the trash isn’t exactly a big deal.
 
#8 ·
OP here - Thanks for the quick replies. I don't intend on using these because I have a few extra NOS USGI springs. I was just curious; someone might want to use them.

I'll look at them closer later today. The USGI spring's ends are open coil; the other two may be closed, but I'll need to verify.
 
#10 ·
Here's a calculator that will get you in the ballpark. As stated above, the specific material isn't all that important...if it's some flavor steel, its elasticity will be about the same. A change from steel to aluminum or titanium, for example, would result in a significant change in elasticity....not at all likely you would have any material other than some variety of steel or sst.

 
#17 ·
OP here - the USGI spring has open ends. Unknown #1 has one open end and one closed end (not ground). Unknown #2 has closed ends (not ground).



I went to this website and played with some numbers. Since the USGI spring is rated for 16 lbs, I plugged in its data. The website said it has 10.74 lb max load. That was the only result in lbs. The USGI spring had a rate (k) of 3.036.

Unknown #1 had 12.32 lb max load and k of 3.415.

Unknown #2 had 7.439 lb max load and k of 1.279.

If I do a little math interpolation (since I know the USGI spec), I figure Unknown #1 is an 18 lb spring, and Unknown #2 is an 11 lb spring.
 
#16 · (Edited)
For some reason spring discussions can become testy, lol. The way gun springs are currently rated as a #16, for example is the force it produces at the full recoil position of the slide. So a 5"GM #16 will register #16 at 1.6125", a Commander spring will register at 1.125", A Kimber Pro .940" an OACP at .700" a Detonics at .500" .

Glock flat wire springs are rated on the full recoil space of either the 19, or 17 as most Gocks no matter the model fall under one or the other of available recoil compression spaces, which are 1.105" for the 17, and .920" for the 19. Note, no one to date is making flat wire recoil springs specifically for the 1911, however they can be used to great advantage as they have more coils.

Something to consider also is the number of coils relates to the compressible length, not to the compression strength, as each coil of equal helix, or the distance of each coils spacing being equal, produce the same resistance at full compression. When a full size 1911 #16 recoil spring is compressed to 1.625" it is very near stacking and producing as much force as it is capable, #16.

So, realize also that if you cut, say a #18 so it registers #16 at the full compressed recoil space of 1.625" it will differ from the uncut #16 when in battery, and be less. So always use a springs whose force at full recoil allows full function, and has the most number of coils so when going to battery it also has sufficient force to smoothly chamber and close.

To clarify and rate recoil springs I highly recommend building a spring tester, you will be able to compare one to another in both the full recoil space as well as the in battery space. The in battery space for the GM it is 3.6875", Commander 3.130", OACP 2.5625", Kimber Pro 2.815", and the Detonics 2.1875". This is without a buffer which will increase the in battery force, but not the full recoil force.

LOG

A full size 5" GM #16 recoil spring compressed to the full recoil space of a 1911.
Image
Image

Image
Image
 
#23 ·
Nice fixture.

Do you notice any problems with friction on the guide rod due to spring buckling?

My fixture is vertical, and uses weights. I find that with a fixed force, the spring will stick at two different compressed lengths over a small range. I have to find the two extremes and use the midpoint as the actual length.

-
 
#19 ·
I used the spring calculator at thespringstore.com to verify the Wolff 16 lb spring specs:

16 lb Wolff govt model spring:

free length 6.5"
active coils 31
wire diameter .045"
coil diameter .431"
mean coil diameter .386"

spring rate from rated power and free length 3.28 lb / in
spring rate from the spring calculator 3.304 lb / in

spring power from the Wolff spec 16.0 lb
spring power from spring calculator rate 16.1 lb

That's pretty good agreement.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

The calculator at thespringstore.com has been unaccesible at times. I only have comparisons for your USGI spring so far:

USGI:

free length 6.55"
active coils 30
wire diameter .044"
coil diameter .438"
mean coil diameter .394" (coil OD - wire diameter)

d = (.044 / .045) ^ 4 = .914
D = (.394 / .386) ^ 3 = 1.06
N = (30 / 31) = .968

as calculated in proportion to the Wolff 16 lb:

spring rate = 3.28 x .914 / (1.06 x .968) = 2.92 lb / in
spring power = 2.92 x (6.55 - 1.625) = 14.4 lb

as calculated from the spring calculator rate:

spring rate = 2.935 lb / in
spring power = 2.935 x (6.55 - 1.625) = 14.5 lb

Also pretty good agreement.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

For the other two springs, these are only in proportion to the Wolff 16 lb.
If I can access the spring calculator again, I expect it will also be in agreement:

Unknown #1:

free length 5.88"
active coils 34
wire diameter .046"
coil diameter .435"
mean coil diameter .389"

d = (.046 / .045) ^ 4 = 1.09
D = (.389 / .386) ^ 3 = 1.02
N = (34 / 31) = 1.10

spring rate = 3.28 x 1.09 / (1.02 x 1.10) = 3.19 lb / in
spring power = 3.19 x (5.88 - 1.625) = 13.6 lb

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

Unknown #2:

free length 6.88"
active coils 44
wire diameter .038"
coil diameter .420"
mean coil diameter .382"

d = (.038 / .045) ^ 4 = .508
D = (.382 / .386) ^ 3 = .969
N = (44 / 31) = 1.42

spring rate = 3.28 x .508 / (.969 x 1.42) = 1.21 lb / in
spring power = 1.21 x (6.88 - 1.625) = 6.36 lb

-
 
#20 ·
OP here - Thanks for that.

So a USGI spring, by US Ordnance values / specs, is actually closer to a 14-lb spring, rather than 16-lb?

I have never changed a spring in any of my 1911's. My 1983-vintage Series 80 Government Model is still stock. I bought a NOS Colt Government spring from Midway for a Remington R1 I'm pseudo-custom building. Unknown #1 came from a Remington Rand M1911A1 as I received it, along with a 2-piece long guide rod. I bought a trio of NOS USGI springs (contract date 1984) off eBay, and have used one in the RR, so I have two spares.

I already knew that the Unknown #2 was a lighter spring just by a "hands-on" examination; I didn't know of a numerical value to associate it with.
 
#21 · (Edited)
OP here - Thanks for that.

So a USGI spring, by US Ordnance values / specs, is actually closer to a 14-lb spring, rather than 16-lb?

I have never changed a spring in any of my 1911's. My 1983-vintage Series 80 Government Model is still stock. I bought a NOS Colt Government spring from Midway for a Remington R1 I'm pseudo-custom building. Unknown #1 came from a Remington Rand M1911A1 as I received it, along with a 2-piece long guide rod. I bought a trio of NOS USGI springs (contract date 1984) off eBay, and have used one in the RR, so I have two spares.

I already knew that the Unknown #2 was a lighter spring just by a "hands-on" examination; I didn't know of a numerical value to associate it with.
Yes, based on the spec. the vintage spec. RS is/was right at #14.

Springs of the same label weight from the same manufacture will vary from one to another, in actual force provided at a given compressed length.

The only way to tell is by actually physically scaling each one.

LOG
 
#22 ·
I think it's safe to say that the Unknown #2 is not a 1911 spring.

First, the solid length would be 1.786". This greatly exceeds the maximum solid length of 1.604" (nominal) for a govt model.
Plus the strength is far too low. And the two closed ends would also be unusual.

The Unknown spring #1 is questionable. The solid length is a bit too long at 1.656". You would have to trim a coil or two off to avoid coil bind (coil stacking).

For Unknown #1, with one closed end, I am adding 1 to the active coil count for a total coil count of 35.
For Unknown #2, with two closed ends, I am adding 2 to the active coil count for a total coil count of 46.

The solid length is (number total coils +1) x wire diameter. That 1 is added because the coils do not lie flat.

-
 
#25 · (Edited)
On 1911 style pistols, there is a balance needed for the weight of the main spring and the weight of the recoil spring. Since I am a DIY gunsmith, I now build most all of my pistols, and prefer the STI 2011 style steel receiver. Although I have the math skills, I don't worry about the mechanical engineering aspects of recoil springs.....I use the trial and error methodology since it gives me the proper results. I want the slide to be a good but not super tight fit, A very tight slide to frame fit has greater potential to impede reliability, but might be ok for a target gun when your life doesn't depend on making every shot count.

A strong mainspring and a light recoil spring may allow very fast slide travel and slam shut on each shot, which may provide poor sight tracking, and less than desirable recovery time on each shot. Optimal sight tracking is attained by the proper balance of the weight of the main spring and recoil spring. I fit my slides and lap them so the slide is a good fit, but easily slides on and off the frame. Once I fit the barrel and the gun locks up consistently, I will take the gun to the range. I have different main spring weights for different calibers of guns, and through my own experience, I usually choose a mainspring weight that will work.....but may have to try different recoil springs to find the best combination to attain ideal sight tracking. The weight of the slide, how the gun locks up, the caliber and power of the ammo, etc., all affect the required main and recoil spring. Many of my STI 2011 9mm guns with a 5" slide work fine with excellent sight tracking for Action Shooting games with an 18lb. mainspring and a 10lb. recoil spring. This works fine when shooting lighter loads for competition. My most often carried self defense gun is an STI 2011 Commander .38 super using hot loaded ammo. Due to the very fast slide velocity when using hot hand loads, I use a 26lb. mainspring, and a 12lb. recoil spring, which provides excellent reliability and sight tracking.

The variables encountered when making a 1911 style pistol, such as the fit of the slide, the way the gun locks up, the type of firing pin stop plate, the bullet profile and the power of the ammo used, will affect which recoil and main spring works best for that pistol. Even how a mag sits in the frame and how high it sits can make a difference in how the ammo is stripped by the slide and where it bounces off the frame and into the chamber. Trying to work out the variables using math is near impossible for me, so I simply use the trail and error method until I get the proper results.....